Fuel For Thought
by Rod Morris
Copyright © 2006 Top Gun Motorcycles. All rights reserved.  Distribution or publication of this document (electronic or otherwise)
is prohibited without the express written consent of the author. For more information or to request permission to publish this
document, please see our
contact page. For information on our pledge to maintain your privacy click here. To learn more about
your friends at Top Gun Motorcycles, read about us
here.
10/01/2010

Welcome To Fuel For Thought

Written by: Rod Morris

Glossary of terms and abbreviations:
MSM - Multisurface Motorcycles/Motorcyclist
MMP - Multisurface Motorcycle Products
TGMP - Top Gun Motorcycle Products

MSM Weight Classifications:
Lightweight (LW) - up to 250lbs
Middleweight (MW) - 251lbs - 300lbs
Light-Heavyweight (LHW) - 301lbs - 350lbs
Heavyweight (HW) - 351lbs - 400lbs
What's NEW!
It wasn't long before we came to realize how
much weather damage a non-maintained
Baja dirt road can sustain over almost two
decades. For the most part Rod and I
negotiated several miles of ditches, whoops
and off cambers. The worst part was the final
2 to 3 miles following a chopped up deep
sand wash which finally came out at the El
Compadre Ranch. What a relief!!

Rod and I understood in reflection why we
saw only dirt bike and ATV tracks during our
ordeal.  If there were any KLR tire tracks in
that wash besides our own they were
probably put there by Big John Brande, the
best KLR-A single tracker we ever knew. But
it couldn't have been John - he now lives on
the east coast.

Aside from the detour through hell that we
had experienced, Rod and I were amazed at
the poor condition of the remaining 40 miles
of the El Compadre Road. Lots of loose sand,
ruts, wash board and storm damaged
sections from the previous winter’s storms.
Not a good place for giant BMW and KTM
twins or even KLRs, especially if you've
added lots of weight up front and installed
raising links.

Upon hitting the pavement at Ojos we aired
the tires up to 24 front/22 rear and headed
west to Ensenada for some good food and
sleep. After a restful overnighter in
Top Gun Motorcycles
Elden meets Goliath!
Bad Baja Roads, by Elden Carl

Even though I've spent the past 20+ years riding, servicing, building and studying
KLR650s, I find I'm still faced with new problems based on changing conditions.  The
same is true with my WR250R, DR350 and DR650s and other bikes I've owned since
being honorably discharged from the military in 1955 (the first was a new 200cc Triumph
Tiger Cub).

With 257,000 miles on KLR-A models (1987 thru 2007) and somewhere close to a
million miles on all the bikes I've owned, there is no way to stop learning if I want to
continue to improve the efficiency and safety of my equipment.

Pauline's 1989 KLR is a case in point. Purchased slightly used in 1990 and owned by
Robert Buchanan from 1994 through 2004 the upgraded old girl (the bike) is still
running strong (so is Pauline). At present the bike is being prepped for a couple of
multisurface rides in Arizona with Bruce Redding, Tex Ernhardt, Eric McKee, Phillip Orth,
Paul Tomlinson and Rod Morris among others.

As with all changes including perceived improvements, testing is an important part of the
development process, especially for a 20 year old motorcycle ridden by a 75 year of
guy. Enter Rod Morris, our off-road riding partner of many years.

About three weeks ago Rod and I headed for Baja on a 300+ mile overnighter to
Ensenada Mexico. We crossed the border at Tecate Mexico 30 miles from our
respective homes and headed east on pavement. About 17 miles out and half a dozen
miles south of the border we aired down all four knobby tires (15psi front and 12psi rear)
and headed south on what has been for years our favorite Baja dirt road, the El
Compadre, which ultimately leads to Ojos Negros, Ensenada, San Felipe, Mike's Sky
Ranch and many other interesting places.

Our first stop was about 15 miles south at the top of a mountain south of Neji Valley. I've
been stopping and looking down on that beautiful valley since my first Baja ride with Alan
Dietor in 1974. Alan was my dirt riding mentor who in 1977 lead Jeff Ziems, David
Kramer and me to a second place team finish in the longest and toughest motorcycle
event of the time, the two day Tecate 500 mile enduro (only two out of about 50 4-man
teams finished intact that year). In all, Alan Dietor was responsible for the 4 Tecate 500
trophies hanging on my wall. Alan, with a half dozen Tecate 500 trophies plus several
thirds through fifths in the much easier but faster Score Baja 500 and 1000 on stock
equipment, is the best dirt rider I have ever ridden with and a heck of a good guy.
Thanks Al! But I digress.

Behind Rod and me where we stopped above Neji Valley was a road I hadn't been on for
15 or 20 years. Since the road ultimately lead to La Prieta's El Compadre Ranch which
we had to pass through anyway, I suggested we try it. After dead ending at several
ranches that hadn't existed the last time I traveled the road I finally found the abandoned
section leading to La Prieta's Ranch.
Please KLR, don't fail me now!
No missing this Mexican flag flying
over Ensenada - Viva Mexico!
Ensenada, Rod and I headed east again to travel back through the mountains via the 60
+ mile Constitutional Park/Laguna Hansen dirt road. Again we experienced much more
difficult road conditions than we expected. Lots of sand and a difficult rocky section
several miles north of the Park.
Giving the bikes a break at Laguna
Hansen
Just north of a particularly rocky area I
waved down an oncoming SUV to warn him
of what was ahead. He didn't have any
protection for his engine pan and I've since
wondered if he made it to Laguna Hansen
with all his oil.

Rod and I were a little bummed out over
road conditions north of Laguna Hansen so
what happened while talking with the young
male SUV driver gave us a welcome lift.  
There, suddenly appearing in the open left
rear window of the vehicle was the largest
dog's head we'd ever seen (see photo). I
could see through the window that the
animals butt was almost touching the rear
passenger door on the other side. After
being assured that "Goliath" (what else?)
would more likely lick my face off than bite
me, I petted and scratched his monstrous
head while Rod snapped a photo of this
half English Bull dog, half Quarter horse
(or something else big). At close to 200 lbs
I'm not used to being out-weighed by a K-9,
but then I was looking at the greatest dog
I'd ever seen! What a guy! "Viva Goliath"

Upon completing our meeting with Goliath
and family, Rod and I continued north on
the dirt another 20 miles to La Rumarosa
where we aired our tires back up to Baja
rough pavement pressure (21psi all
around). From La Rumarosa to the Tecate
border crossing and on to our respective
residences in Crestwood and La Mesa Rod
and I put another 70 or so miles on the
KLR clocks.
I had decided while fighting the deep chopped up sandy road sections on this trip that I
wasn't going to wait for the grader that may not do his work before winter arrives. After
comparing notes with Rod who, like me, had considerable difficulty negotiating some deep
sandy sections of road chopped up by 4 wheeler tracks that crisscrossed each other
creating waves which constantly deflected the front wheel from one rut to another, I came
up with a plan.

I wanted to stabilize the front end thereby reducing the severity of the cross-grain impacts
on the front wheel. The changes not only made the front end easier to control, but at the
same time slowed the deflection process down allowing the pilot more time to take
corrective action.

How do I know it worked? Well, Rod Morris and I took the same 300 mile trip in reverse two
weeks later and immediately after I had completed some modifications mostly at the front
end.  Forgive us but we omitted the section from hell near Rancho El Compadre. The
changes I made both up front and at the rear of the 1989 "A" model KLR650 are detailed
in
Technical Insights.

I'm pleased enough with the results that I obtained due to the changes made that I wish I'd
come up with them years ago. One thing is for sure, the modifications accomplished are
here to stay on my MSM A Model. Rod is considering at least part of the modifications on
his MSM KLR. His pavement KLR like mine will remain with near stock rake and trail and
equipped with a 19" front wheel.

NOTE:
In order not to lose rake and trail upon installing a 19" front wheel and 100/90 X 19 tire,
don't forget to drop the rear approximately 1" with lowering links. Obviously this will lower
your KLR approximately 1" overall reducing your lean angle and ground clearance. You
shouldn't make such a change if you are a radical rider and/or have weak springs front
and rear. Our street KLR's have Progressive springs up front and Top Gun spring at the
rear.